Nilfisk br 755 коды ошибок

MAIN CONTROLLER ERROR CODES – ADVENGER / BR 755, 855 AND ST

Advenger /

ST Service

BR 755, 855

LED Blink

Display Error

Code *

Code

3

1,1

4

NA

5

1, 2

6

NA

7

1, 3

8

1, 4

9

2, 1

10

2, 2

11

NA

30

2, 3*

31

2, 4

32

NA

33

3, 1

34

NA

35

3, 2

36

3, 3

37

NA

60

3, 4

61

4, 1

62

4, 2

63

4, 3

64

4, 4

* ST open circuit errors are only visible in Fault Recall Mode, accessible via the Hidden Menu. Refer to «Changing Program Settings — ST» section.

Then verify fault by entering Service Test Mode.

Fault Description

Speed control fault

Scrub deck lift actuator overload

Brush motor overload

Squeegee lift actuator overload

Vacuum motor overload

Solution solenoid overload

Vacuum contactor coil overload

Brush motor contactor coil overload

Chemical pump overload

Solution solenoid open

Brush motor circuit open

Scrub deck lift actuator open

Vacuum motor circuit open

Squeegee lift actuator open

Brush motor contactor coil open

Vacuum motor contactor coil open

Chemical pump open

Brush motor circuit contacts stuck closed

Vacuum motor circuit contacts stuck closed

Solution solenoid control fault

Brush contactor coil control fault

Vacuum contactor coil control fault

FORM NO. 56043121 — Advenger / 2800ST, 3400ST / BR 755, BR 855 — 15

System

Refer to page:

Affected

Wheel Drive

52

Scrub

32

Scrub

31

Squeegee

21

Recovery

42

Solution

47

Recovery

42

Scrub

31

AXP/EDS

47

Solution

47

Scrub

31

Scrub

32

Recovery

42

Squeegee

21

Scrub

31

Recovery

42

AXP/EDS

47

Scrub

31

Recovery

42

Probable board failure

Probable board failure

Probable board failure

Скачать

• 2, A-2 / ENGLISH A-2 — FORM NO. 56041743 — BR 755 series TABLE OF CONTENTS Page Introduction ………………………………………………………………………………. A-2 Cautions and Warnings ………………………………………………………………A-3 Know Your Machine ……………………………………………………………A-4 – A-5 Control Panel …………………………………………………………………….…

• 9, ENGLISH / A-9 FORM NO. 56041743 — BR 755 series — A-9 INSTALL THE SQUEEGEE 1 See Figure 4. Slide the Squeegee Assembly (11) onto the squeegee mount bracket and tighten the Squeegee Mount Thumb Nuts (AA). 2 Connect the Recovery Hose (AB) to the squeegee inlet. 3 Lower the squeegee, move the machine ahead slightly and adjust the squeegee tilt and height using the Squeegee Tilt Adjust Knob (32) and Squeegee Height…

• 17, ENGLISH / A-17 FORM NO. 56041743 — BR 755 series — A-17 SIDE SKIRT MAINTENANCE The side skirts’ function is to channel the waste water to the squeegee, helping contain the water within the machine’s cleaning path. During normal use the blades will wear in time. The operator will notice a small amount of water leaking out underneath the side skirts. A height adjustment can easily be made to lower the blades so that all the water can be picked up by the s…

• 35, TÜRKÇE / B-17 FORM NO. 56041743 — BR 755 series — B-17 YAN ETEKLİĞİN BAKIMI Yan etekliğin işlevi, atık suyu lastik sileceğe iletmek ve suyun makinelerin temizleme yolu üzerinde kalmasını sağlamaktır. Normal kullanım koşullarında bıçak ağızları zaman içinde aşınacaktır. Operatör yan etekliklerin altından dışarıya sızan az miktarda su fark edecektir. Bıçak ağızlarını alçaltarak lastik sileceğin tüm su…

• 16, A-16 / ENGLISH A-16 — FORM NO. 56041743 — BR 755 series SQUEEGEE MAINTENANCE If the squeegee leaves narrow streaks or water, the blades may be dirty or damaged. Remove the squeegee, rinse it under warm water and inspect the blades. Reverse or replace the blades if they are cut, torn, wavy or worn. To Reverse or Replace the Rear Squeegee Wiping Blade… 1 See Figure 7. Raise the squeegee tool off the fl oor, then unsnap the Rea…

• 5, ENGLISH / A-5 FORM NO. 56041743 — BR 755 series — A-5 KNOW YOUR MACHINE 21 Solution Shutoff Valve 22 Solution Filter 23 Steering Wheel Tilt Adjust Knob 24 Control Panel 25 Solution Tank Fill Cover 26 Recovery Tank Cover 27 Vacuum Motor Filter Housing 28 Strainer Basket 29 Recovery Tank Shutoff Float 30 Squeegee Storage Hook 31 Recovery Tank Drain Hose 32 Squeegee Tilt Adjustment Knob 33 Seat Prop-Rod 34 Machine Battery Connector 35 Rear Squeegee Blade Removal Latch 36 …

• 36, B-18 / TÜRKÇE B-18 — FORM NO. 56041743 — BR 755 series GENEL ARIZA TESPİT VE GİDERİLMESİ Problem Muhtemel Sebebi Çözümü Yetersiz su toplanması Çekçek ünitesi bıçakları aşınmış veya yırtık Ters yüz çevirin veya değiştirin Çekçek ünitesi ayarı bozuk Bıçaklar tam genişlikte zemine dengeli değecek şekilde ayarlayın Geri kazanma tankı dolu Geri kazanma tankını boşaltın Geri kazanma tankı tahliye hortumu sızdırm…

• 6, A-6 / ENGLISH A-6 — FORM NO. 56041743 — BR 755 series CONTROL PANEL A Key Switch B Solution Increase Switch C Solution ON/OFF Switch C1 Solution Flow Indicators (Normal, Heavy & Extreme) D Solution Decrease Switch E Detergent ON/OFF Switch F Display F1 Hour Meter F2 Solution Tank Level Indicator F3 Fault Codes F4 Detergent Indicator (if so equipped) F5 Detergent Percentage Indicator F6 Battery Indicator F7 Recovery Tank FULL Indicator F8 …

• 26, B-8 / TÜRKÇE B-8 — FORM NO. 56041743 — BR 755 series FIRÇALARIN TAKILMASI (DİSK SİSTEMİ) DİKKAT! Fırçaları değiştirmeden ve herhangi bir erişim panelini açmadan önce kontak anahtarını kapatın (O) ve anahtarı çıkartın. FIRÇALARIN TAKILMASI (SİLİNDİR SİSTEMİ) DİKKAT! Fırçaları değiştirmeden ve herhangi bir erişim panelini açmadan önce kontak anahtarını kapat�…

• 23, TÜRKÇE / B-5 FORM NO. 56041743 — BR 755 series — B-5 MAKİNENİZİ TANIYIN 21 Çözelti Kesme Valfı 22 Çözelti Filtresi 23 Direksiyon Eğimi Ayar Düğmesi 24 Kontrol Paneli 25 Çözelti Deposu Doldurma Kapağı 26 Geri Alma Deposu Kapağı 27 Vakum Motoru Filtre Karteri 28 Süzgeç Sepeti 29 Geri Alma Deposu Kesme Şamandırası 30 Lastik Silecek Saklama Kancası 31 Geri Alma Deposu Akıtma Hortumu 32 Lastik Silecek Eğim Ayar Düğmesi 33 Koltuk Destek Çubuğu 34 …

• 33, Nilfisk-Advance BR 755 TÜRKÇE / B-15 FORM NO. 56041743 — BR 755 series — B-15 SULU AKÜLERİN ŞARJ EDİLMESİ Makineyi her kullanımda veya Akü Göstergesi (F6) doludan az gösterdiğinde aküleri şarj edin. UYARI! Aküleri şarj etmeden doldurmayın. Aküleri iyi havalandırılan bir yerde şarj edin. Akülere bakım yaparken sigara içmeyin. Akülere bakım yaparken… Tüm mücevherleri çıkarın  Sigara içmeyin  Koruyucu gözlük, l…

• 25, Nilfisk-Advance BR 755 TÜRKÇE / B-7 FORM NO. 56041743 — BR 755 series — B-7 AKÜLER Makineniz aküler monte edilmiş olarak geldiyse aşağıdakileri yapın: Akülerin makineye bağlı olduğundan emin olun  (34). Kontak Anahtarını  (A) AÇIK konuma getirin ve Batarya Göstergesini (F6) kontrol edin. Ölçü aleti tamamen dolu ise, bataryalar kullanıma hazırdır. Ölçü aleti dolu değilse, bataryalar kull…

• 11, ENGLISH / A-11 FORM NO. 56041743 — BR 755 series — A-11 DETERGENT SYSTEM PREPARATION AND USE (ECOFLEX MODELS ONLY) DETERGENT ENABLED DETERGENT DISABLED FULL (RESET) Press and hold (B) & (D) for 3 seconds to Reset. LOW DETERGENT PURGE Press and hold (C) & (E) for 3 seconds to Purge. Detergent system is ON when indicator is ON. revised 1/10
  …

• 3, Nilfisk-Advance BR 755 ENGLISH / A-3 FORM NO. 56041743 — BR 755 series — A-3 CAUTIONS AND WARNINGS SYMBOLS Nilfi sk uses the symbols below to signal potentially dangerous conditions. Always read this information carefully and take the necessary steps to protect personnel and property. DANGER! Is used to warn of immediate hazards that will cause severe personal injury or death. WARNING! Is used to call attention to a situation that could …

• 20, B-2 / TÜRKÇE B-2 — FORM NO. 56041743 — BR 755 series İÇİNDEKİLER Sayfa Giriş ………………………………………………………………………………………… B-2 Önlemler ve Uyarılar ………………………………………………………………….. B-3 Makinenizi Tanıyın ……………………………………………………………..B-4 – B-5 Kontrol Paneli…